Intense Friday

This day began with Odell and Steven in the mudroom bath at 8 am, talking through how to correct issues with the sink drain. We conclude that the P-trap comes off, the drain line in the wall needs to shift x inches left — and, after this surgery is performed, a T-trap will mount perpendicular and plumb correctly under the sink drain.

The Time Warner techies arrived about 815 am — first Erich, then Cory, then a team in hard hats to string wire from the telephone poles, then a supervisor. Everyone parked their own trucks, with orange cones. Steven should have charged for parking. They wrapped about 130 pm with TV, phone and, most important, Internet up and running — even WiFi. This milestone enables Steven to work at the house without tethering to his phone.

Steven dropped Jadin at school about 845 am.

Steve the electrician arrived to install the whole-house and telephone/cable surge suppressors. The whole-house unit was a 15-minute slam dunk on the exterior of the back wall of the garage. Done. The tele/cable suppressor required research, with Steven struggling to learn more electrical science. We convened a conference — Steven, Steve, Erich and Cory — on the driveway, alongside one of the Time Warner trucks. Erich and Cory advised that the tele/cable suppressor is not needed, because the Time Warner equipment comes with suppression/protection built in. Steven decides: He will return the tele/cable suppressor for a refund.

The HVAC team arrived from Austin Air to determine how and where to install the make-up air system demanded by the Austin Green Build program. This has to be wired to operate when the exhaust hood in the kitchen switches on — the exhaust system blows out, the make-up air system brings in replacement air. The system requires ducting, and a motor to pull in outside air and blow it into the kitchen. Planning is critical — where to put all of this stuff in a house that is nearly complete? They worked at first with Cris and Odell from Ranserve, then roped Steven into the conversation. Everyone climbed up into the attic over the garage to map out one route into the kitchen. Cris sketched the install on the back of piece of drywall leaning against a garage wall. Then we shifted into the kitchen to look at where the duct might mount — near the kitchen-side door. Then we explored a second option — cutting open the kitchen ceiling to route the motor and duct into the cavity under the roof eaves. This second route would leave a huge grille in the kitchen ceiling visible from everywhere. The better location is over the door. With that decided, Cris cut open a section of mudroom ceiling between the garage and the kitchen — see photo above — to confirm that we can route the duct intake at the eave outside the garage, into the garage attic, connect to the motor when it is installed in the attic, run duct above the mudroom, through the framing between the mudroom and kitchen, to the grille above the kitchen-side door.

Why was all this not done when the house was gutted down to studs?

Brett Grinkmeyer arrived to conduct the architectural inspection required when Ranserve requests a draw payment. Steven and Brett barely got time to speak, because it was time for Time Warner to sit Steven down on the upstairs hall floor, laptop propped on boxes, to configure the network, create a Time Warner customer account complete with passwords, sign off on the install.

Victor Martinez arrived to discuss landscaping — using the dirt piled up on the driveway and mulch piled between the trees to fill in around the concrete pavers and spaces made bare of grass by nine months of construction. Steven requests a plan he can submit to Austin Green Build — and a budget.

At 2 pm, approximately, Odell returned from an offsite meeting to review the mudroom plumbing — he thinks he has it figured out; it will require opening up a wall to shift the drain pipe to the proper location. And the routing solution for the make-up air system. And the rough plan for the week ahead.

Steven called Kristin at Harway to ask why the cooktop does not fit absolutely flush to the quartz countertop. There’s a gap about 1/16th inch between the induction cooktop and the quartz countertop — guaranteed to trap food and spills. Late in the day, Kristin responds by email to report she will visit to inspect.

230 pm — lunch break.

Steven comes back from lunch at 3 pm to discover Bassam working on the kitchen cabinets.

At 330, Lance from Time Warner calls to close out the install ticket.

At 345, Steven departs to pick up Jadin from school.

Observation — at several times today, especially in the morning, the questions were firing in, one on top of the other, stacking up over Newark. Each issue required thought and discussion — where to put the tele-cable surge suppressor, for example — it can’t mount outdoors, so why does it mate to the whole-house suppressor that does mount outdoors, is it needed? How to address the drain for the mudroom sink — that took at least an hour, on and off, back and forth, testing ideas, researching options. It was intense. Everything was way above Steven’s pay grade — he’s not a plumber, not an electrician, not an HVAC installer, not a cable tech, not a cabinetmaker, not a landscaper. Steven misses Ron, who seemed able to work through any stress, calmly, expertly, guiding with advice. In his first 48 hours on the job, Odell is quickly coming up to speed. But, damn, we have not had a day like this in a long time — not since Steven and Ron climbed into the 120-degree attic to unravel the botched HVAC ducting.

 

Leave a Reply